EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF FINE AGGREGATE WITH QUARRY
Quarry dust is a waste obtained during quarrying process. It has very recently gained good attention to be used as an effective filler material instead of fine aggregate. Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the partial replacement for natural river sand.
اقرأ أكثر
Comparing the Compressive Strengths of Concrete Made …
3. RESULTS AND ANALYSIS In order to achieve the objective of this work various laboratory tests were conducted on sand as fine aggregate and quarry dust as fine aggregate as well, also the concrete derived from them were tested in their fresh and hardened states. Below are presentation of data and a detailed discussion on the results obtained.
اقرأ أكثر
Strength and durability of concrete by partial replacement …
Replacement of quarry dust with fine aggregate at a ratio of 30 percent produces the best results, but beyond that, the strength obtained gradually diminishes. It has been shown that increasing the proportion of quarry dust in concrete may increase its workability by as much as thirty percent for M40 grade concrete.
اقرأ أكثر
Properties of cold bonded quarry dust coarse aggregates and …
The quarry sand is the coarse fraction of the quarry powder and is being used as the fine aggregate in place of river sand in concrete production [3]. The fine quarry dust fraction is commercially unused material [4]. Therefore, utilization of waste material quarry dust in the production of artificial aggregates is examined in this study.
اقرأ أكثر
Study on Strength of Concrete using Lateritic Sand and Quarry Dust …
This is part of a research on the structural characteristics of concrete using lateritic sand and quarry dust as fine aggregate. This paper presents the results of an experimental study investigating the flexural and tensile characteristics of concrete using combinations of lateritic sand and quarry dust as complete replacement for conventional river sand fine aggregate.
اقرأ أكثر
Fine Aggregate for Concrete: 3 Classification, …
Crusher Dust/Quarry Dust: Byproducts of the crushing process in quarries, crusher dust or quarry dust can also be used as a fine aggregate. These materials are finely graded and can contribute to improving the …
اقرأ أكثر
Performance of Sustainable Green Concrete Incorporating …
Use of quarry dust and nickel slag as fine aggregate produced a higher uniaxial compressive strength of concrete than that using sand. Specifically, QD25-FNS75 had the …
اقرأ أكثر
Partial Replacement of Fine Aggregates with Quarry Dust …
Quarry dust and Marble powder are the most used among such materials to replace river sand, which can be used as alternative to fine aggregate in concrete. In the present investigation workability and strength of concrete was evaluated by replacement of natural sand by Quarry dust and marble powder in equal proportions of 0%, 10%, 20%, 30%,40% ...
اقرأ أكثر
Concrete Compressive Strength Using River Sand and Quarry Dust as Fine
Properties of Green Concrete Containing Quarry Rock Dust and Marble Sludge Powder as Fine Aggregate", ARPN journal of Engineering and Applied Science, 4( 4): 83-89. Ilangovana,R., Mahendrana, N., Nagamanib,K., 2008. Strength and durability properties of concrete containing quarry rock dust as fine aggregate, ARPN J. Eng. Appl. Sci., (3)20-26.
اقرأ أكثر
An Experimental Study on Quarry Dust as a Fine …
strength of concrete for grade M30 with quarry dust as fine aggregate were found to be comparable with the concrete made with the river bed sand. 4. The increase in compressive strength of concrete with 30% replacement and 50% replacement of fine aggregate with stone dust is found to be 8 to 10%. 5.
اقرأ أكثر
Study on Performance of Quarry Dust as Fine …
The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%, 40%, 60%, 80% partial replacement of ...
اقرأ أكثر
A comparative experimental study on concrete usingstone dust …
The current study demonstrates that stone dust can be used as a fine aggregate material in the concrete due to its high strength and durability. The stone dust has been collected from a stone cutting plant which situated at Bharatpur (Rajasthan), near the Achnera cold storage.
اقرأ أكثر
(PDF) Assessment of Laterized Quarry Dust and Crushed …
Zone 1 curve for fine aggregates defines the quarry dust as a fine aggregate of a coarser gradation which enhanced the behavior of appreciable workability from the W/C ratio 0.6-0.7 hence slump and Compacting Factor values of (i.e. 10-50mm, 0.8-0.95) respectively.
اقرأ أكثر
Performance of Sustainable Green Concrete Incorporating Quarry Dust …
This paper presents a study on the combined use of two by-products, namely quarry dust (QD) and ferronickel slag (FNS), as a full substitute for natural sand to improve the greenness of concrete production. Quarry dust was used in increments of 25% to a maximum of 75% substitution, where nickel slag was used as the remaining proportion of fine aggregate. …
اقرأ أكثر
Prediction of Strength Properties of Concrete Containing …
In the current study, marble waste aggregate (MWA) and stone dust (SD) were used as partial replacements for coarse aggregate and fine aggregate, respectively, for normal strength concrete. The conventional mix design had a mix ratio of 1:2:4 of cement: fine aggregate: coarse aggregate, respectively, and a water to cement ratio of 0.5.
اقرأ أكثر
concrete with fine aggregate and quarry dust aggregates
replacement of fine aggregate with quarry dust in . EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete.
اقرأ أكثر
An experimental analysis on the replacement of fine aggregate …
Stone dust can substitute river sand as fine aggregate in concrete. Ceramic waste can replace 10–20% of coarse aggregates without impacting material structure. Ceramic waste can replace coarse aggregates [17]. The mechanical characteristics of normal concrete with quarry dust (2011). In the experiment, quarry dust replaced sand of the time.
اقرأ أكثر
Review-Experimental Investigation on Quarry Dust as a …
respectively. Cubes cylinders and beams will be casted by a partial replacement of natural fine aggregate in concrete mix and quarry dust will be used as a fine aggregate. Keywords: Quarry, water cement ratio, Cubes, Cylinders, beams, fine aggregate 1. INTRODUCTION Rapid industrialization in developing countries is increasing in urbanized areas.
اقرأ أكثر
COMPRESSIVE STRENGTH OF CONCRETE USING …
sand and quarry dust as fine aggregate Joseph O. Ukpata 1, Maurice E. Ephraim 2 and Godwin A. Akeke 1 1 Department of Civil Engineering, Cross River University of Technology, Calabar, Nigeria
اقرأ أكثر
Compressive strength of concrete using lateritic sand and quarry dust
2012. This is part of a research on the structural characteristics of concrete using lateritic sand and quarry dust as fine aggregate. This paper presents the results of an experimental study investigating the flexural and tensile characteristics of concrete using combinations of lateritic sand and quarry dust as complete replacement for conventional river sand fine aggregate.
اقرأ أكثر
Strength of Concrete with Ceramic Waste and Quarry Dust as Aggregates
PDF | This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources... | Find, read and cite all the research ...
اقرأ أكثر
UTILISATION OF AS GENERATED QUARRY DUST AS A …
and 30 concrete. As for grade 20, quarry dust concrete records a lower compressive strength than river sand concrete. As generated quarry dust can be recommended to be used as a fine aggregate in structural concrete for higher grades. REFERENCES BS 882:1992, Specification for aggregates in concrete from natural sources for concrete.
اقرأ أكثر
Partial Replacement of Fine Aggregate with Quary Dust …
2. Fine Aggregate:- Fine aggregate of 10mm fine m-sand is used. 3. Coarse Aggregate:- Coarse aggregate used in this are size of 15cm. 4. Red Soil:- 10 mm fine red soil is been used. MIX DESIGN AND SAMPLE PREPARTION The concrete mixture have been made with 100 % replacement of fine aggregate with quary dust and red soil in
اقرأ أكثر
EXPERIMENTAL INVESTIGATION ON PARTIAL …
The ingredients of concrete consist of cement, fine aggregate and coarse aggregates, water. When the reaction of water with cement takes place hydration process is done and a hard material is formed. In this project work we used quarry rock dust as a partial replacement of fine aggregate and fly ask replaced by cement.
اقرأ أكثر
COMPARATIVE ANALYSIS OF COMPRESSIVE STRENGTH OF CONCRETE …
Test results showed that concrete made from quarry dust has the highest workability followed by concrete made from crushed palm kernel shell, crushed groundnut s hell and sawdust fine aggregate ...
اقرأ أكثر
Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete
A total of 18 different mix proportion designs were developed at different combinations of aggregates, namely Natural Coarse Aggregates (NCA), Recycled Coarse Aggregates (RCA), River Sand Fine ...
اقرأ أكثر
Utilization of quarry dust and periwinkle shell ash in concrete
In this study, the physical and mechanical properties of concrete made by partially and fully substituting fine aggregates and ordinary Portland cement with periwinkle shell ash …
اقرأ أكثر
" Use of Quarry Dust as fine aggregates by Partial Replacement of …
Quarry dust is a waste obtained during quarrying process. It has very recently gained good attention to be used as an effective filler material instead of fine aggregate. Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the partial replacement for natural river sand.
اقرأ أكثر
REPLACEMENT OF FINE AGGREGATE WITH SAWDUST
CMs and derivatives offer sustainable ways to be used as fine aggregates, reinforcements, and cement replacements. ... Comparison of compressive strength of the saw dust concrete mix with ...
اقرأ أكثر
Strength and Durability Properties of Concrete …
Keywords: Strength and Durability Properties, Concrete, Quarry Rock Dust, Fine Aggregate 1. Introduction Concrete is a blend of cement, sand, aggregate and water in precise proportions that harden to a solid stony consistency ... the aggregates as the particle size is less. The same method Paper ID: 24041805 DOI: 10.21275/24041805 418 .
اقرأ أكثر